Blue Springs, MO HVAC & Plumbing Services

N

Furnace has a bad control board. Thank you for choosing LBA services!

L

L

L

L

Investigated and estimated needed airflow needs.

Upon arrival I began the AC tune up. First, I ran a static pressure test. This unit has a max rating of .5 and the system is testing at 1.14 at arrival. This was way too high and putting a ton of stress on the system. Next, I checked the blower speeds and noticed it was setup for a 5 ton system and this only has a 4 ton system so I lowered the blower speed down for a 4 ton and then the static wasn’t failing as bad at .85 but still above the max allowed. Field Supervisor Adam has arrived to help find a solution to the lack of airflow in the system. I continued my tune up. The refrigerant charge on the outdoor unit looks good and within specs. The compressor and fan motor are running within manufacturer specifications. The dual run Turbo200 Capacitor was testing within specs on both sides. My temp split at departure was up to 22 degrees which is a good temp split. Once the airflow is addressed, your system will last much longer than it would if nothing is done to correct the airflow. If

Left a voicemail, returning earlier call to the office.

Put camera and back pack auger down main stack, pulled toilet ran camera down, preformed plumbing inspection, turned over to supervisor

Inspected and located obstruction in main sewer line. Following up with estimates.

Completed cooling maintenance on all 4 rtus. Cleaned coils, changed filters, checked amp draw on compressors, checked amp draw on motors, checked motor bearings, checked temp split. Unit is functioning properly at this time

Dispatch for humidifier leaking in the utility room. After inspecting the humidifier and drain lines. I found the compression bolt on the outlet side of the solenoid leaking. After tighten the compression bolt, there was still water flowing out of the drain line. After examining the drain line, I discovered it was flowing back towards the furnace. This was creating it to not drain and was back-flow flowing. After correcting the pitch of the drain the water from the humidifier and the condensation from the furnace flow to the drain. Thank you for choosing LBA services.

WH, PRV, spigots

Inspected outdoor faucets, preformed plumbing inspection, presented findings to customer, turned over to supervisor

Sewer and floor drain

Ran camera through drain, preformed plumbing inspection, showed findings to customer, turned over to supervisor

Shower and toilet

Inspected shower drain and toilet turned over to supervisor

Arrived for ac maintenance today. Checked static pressure and it is passing right now. Refrigerant charge looks good. Fan and compressor amps are within specs. Contactor and capacitor are within specs. There’s a 23 degree temp split. Blower wheel is dirty, along with the ducts. Discussed some options for cleaning and you will reach back in a few months to talk with someone again. System is running upon departure. Thanks for choosing LBA.

For maintenance on a AC and furnace. The system is a little over a year old and is operating flawlessly. Refrigerant levels are good and all safety switches and gas and pressure readings are in the green.

Filter would fall out of track after system would shutdown. I moved the tracks inward to support the filter more accurately. Thank you for chooseing LBA Services.

Found gas line rubbing the ductwork causing the annoying squeaking sound. Adjusted gas line so it won’t touch the ductwork and taped up area in case it moves back over. With the tape there it should prevent the quelling sound.

Wife will speak with husband about estimates to fix.

Inspected water heater for a place to put an expansion tank